Alternator; starter batteries; LPG system

Saturday was a really productive boat day.

In the morning, Jamal, a Malay marine electrician recommended by Neo of Best Marine, came by to help me with the alternator installation.  I’m pretty glad I got some help: I think I would’ve gotten things mostly right, but he was really quick, had some spare parts with him that I didn’t have, and obviously had a lot of experience.  He added an additional washer to the pivot bolt to protect the alternator and reduce vibration, which should reduce wear on the belt.  He also put a proper terminal on the tachometer power wire, and fixed a terminal on one of the large DC ground wires going to the engine block that I’d noticed was loose.  Here’s the new alternator, installed:

Once the alternator was in place, I was really surprised that the engine fired up immediately with no problems.  (The battery switch was on “both” so the house bank was helping.)  Checking the voltage coming out of the alternator showed only 7-8V, which was wrong.  Jamal quickly (and correctly) guessed that the starter batteries were completely dead.  I hadn’t realized it, since they still showed 12.5V+; but turning the engine over with the starter bank, the voltage dropped to around 6.  In the end, that’s probably what killed the old alternator: it was hooked directly into the starter bank, which wasn’t accepting a charge, overloading the alternator and eventually burning it out.

Luckily I’ve got a whole bunch of new batteries sitting around (still waiting for a new electrical system), so we just went ahead and replaced the starter bank.  After that the new alternator was performing as expected.

The tachometer is working again too; here it is (along with the rest of the gauges) with the engine at a low idle:

Later I ran the engine for a while at 1500 RPM with no problems.  Brian suggested I should probably run it in gear for at least a couple hours a week (and in neutral before and after), but I still need to go for a swim and cut what appears to be a chunk of fishing net off the prop before I do that.

Here’s a quick video of the new alternator with the engine running; the gauges; and the exhaust pumping out of the stern:

After Jamal left, Charlene lent me a hand and we installed the new fittings and hose for the LPG system.  Everything was pretty straightforward.  First, here’s the stuff I spent most of Thursday morning trying to find; the fitting on the left is the original, and the fitting on the right is the newly built one with barbed ends:

And here I am tinkering with the fitting:

And finally, here’s the new setup.  The hose on the lower right is headed through a deck fitting to the galley stove.  The too-long hose on the left goes to the grill.  (This evening I cleaned it up a bit and secured it with some zip ties.)

Did some leak testing and tried everything out; it all works great.  The grill is really hot.  We haven’t grilled anything yet but will probably give it a shot this coming weekend.

3 Comments

Filed under electrical, galley, liveaboard, maintenance, mechanical, photos, videos

3 Responses to Alternator; starter batteries; LPG system

  1. Greg

    Hi,
    Glad your engine is working!
    By the way, do you have any advice where is the best place to get a sailboat similar to yours.
    Would below SDG 100K be sufficient for a 40 ft boat?
    i guess berthing would costs SDG500.000 a month live onboard.
    i am a newbie. i think its a great lifestyle.
    Cheers,
    Greg

    • Kris

      Hi Greg,

      I’ve actually had a few people ask this question. I think the best places to look for boats like this around Singapore are probably in Phuket (Thailand), and in a few places in Malaysia (Langkawi, Sebana Cove, etc). My boat was in Phuket before I bought it. I looked at brokers like Lee Marine, Pippen Marine, Boatshed Phuket, Simpson Marine, etc.

      I think you can probably find some boats similar to mine in the SGD$100K-120K range.

      Berthing costs really depend on where you keep the boat. I can only really speak to One 15 Marina where I am (it’s closer to SGD$800/month), but I expect some of the farther marinas (Raffles, Changi) are probably around $500 for a 40 ft boat.

      Best of luck in your search!

  2. Pingback: Engine quotes; LPG overhaul; NMEA; transom | Oia

Leave a Reply to Greg Cancel reply

Your email address will not be published. Required fields are marked *